DG130R-ARMAD-1
主要產品：日本東方馬達，韓國DKM減速電機，泰映TROY減速電機，韓國SPG小功率
馬達，CPG晟邦減速電機 ...
銷售熱線: 180-6090-9625/0592-6013512
聯系人：蘭工
QQ: 869740621
減速機技術資料：
在選擇減速機的型號時應注意的幾個事項：盡量選用接近理想減速比：減速比=伺服馬達轉速/減速機出力軸轉速扭力計算：對減速機的壽命而言，扭力計算非常重要，并且要注意加速度的最大轉矩值（TP），是否超過減速機之最大負載扭力。
適用功率通常為市面上的伺服機種的適用功率，減速機的適用性很高，工作系數都能維持在1.2以上，但在選用上也可以以自己的需要來決定，要點有二：A.選用伺服電機的出力軸徑不能大于表格上最大使用軸徑；B.若經扭力計算工作，轉速可以滿足平常運轉，但在伺服全額輸出時，有不足現象時，我們可以在電機側之驅動器，做限流控制，或在機械軸上做扭力保護，這是很必要的。
通用減速機的選型包括提出原始條件、選擇類型、確定規格等步驟。
相比之下，類型選擇比較簡單，而準確提供減速器的工況條件，掌握減速器的設計、制造和使用特點是通用減速器正確合理選擇規格的關鍵。
規格選擇要滿足強度、熱平衡、軸伸部位承受徑向載荷等條件。
1.按機械功率或轉矩選擇規格（強度校核）通用減速器和專用減速器設計選型方法的最大不同在于，前者適用于各個行業，但減速只能按一種特定的工況條件設計，故選用時用戶需根據各自的要求考慮不同的修正系數，工廠應該按實際選用的電動機功率（不是減速器的額定功率）打銘牌；后者按用戶的專用條件設計，該考慮的系數，設計時一般已作考慮，選用時只要滿足使用功率小于等于減速器的額定功率即可，方法相對簡單。
通用減速器的額定功率一般是按使用（工況）系數KA=1（電動機或汽輪機為原動機，工作機載荷平穩，每天工作3~10h，每小時啟動次數≤5次，允許啟動轉矩為工作轉矩的2倍），接觸強度安全系數SH≈1、單對齒輪的失效概率≈1%，等條件計算確定的。
所選減速器的額定功率應滿足：PC=P2KAKSKR≤PN式中PC———計算功率（KW）；PN———減速器的額定功率（ KW）；P2———工作機功率（KW）；KA———使用系數，考慮使用工況的影響；KS———啟動系數，考慮啟動次數的影響；KR———可靠度系數，考慮不同可靠度要求。
目前世界各國所用的使用系數基本相同。雖然許多樣本上沒有反映出KS\ KR兩個系數，但由于知己（對自身的工況要求清楚）、知彼（對減速器的性能特點清楚），國外選型時一般均留有較大的富裕量，相當于已考慮了KR\ KS的影響。
由于使用場合不同、重要程度不同、損壞后對人身安全及生產造成的損失大小不同、維修難易不同，因而對減速器的可靠度的要求也不相同。系數KR就是實際需要的可靠度對原設計的可靠度進行修正。它符合ISO6336、GB3480和AGMA2001—B88（美國齒輪制造者協會標準）對齒輪強度計算方法的規定。目前，國內一些用戶對減速器的可靠度尚提不出具體量的要求，可按一般專用減速器的設計規定（SH≥1.25，失效概率≤1/1000），較重要場合取KR=1.25=1.56左右。
2、熱平衡校核通用減速器的許用熱功率值是在特定工況條件下（一般環境溫度20℃，每小時100%，連續運轉、功率利用率100%），按潤滑油允許的最高平衡溫度（一般為85℃）確定的。條件不同時按相應系數（有時綜合成一個系數）進行修正。
所選減速器應滿足：PCt=P2KTKWKP≤Pt式中 PCt———計算熱功率（KW）；母線加工機KT———環境溫度系數；KW———運轉周期系數；KP———功率利用率系數；Pt———減速器許用熱功率（KW）。
3.校核軸伸部位承受的徑向載荷通用減速器常常須對輸入軸、輸出軸軸伸中間部位允許承受的最大徑向載荷給予限制，應予校核，超過時應向制造廠提出加粗軸徑和加大軸承等要求。
OMRON # 3G2A6-OC222 PROG.CONTROLLER NEW IN BOX
OMRON Z4LB -CV2 PARALLEL BEAM SENSOR
Siemens 6ES5430-4VA13 Digital Input Module
OMRON C28K-CDR-D1020C *NEW OUT OF A BOX*
OMRON CS1W-MCH71 MOTION CONTROL UNIT CS1WMCH71, MCH71
OMRON P5+ SERIES AC DRIVE
OMRON OUTPUT UNIT 3G5A2-OC221 B500-OC221
Magnetek GPD 315 MVA025 / Omron IDM 3G3MV 7.5 HP, 230V
OMRON PJLH-55 LJLH55 Video Memory x3
OMRON V530-R160/F150-KP
OMRON # 3G2A6-OD412 PROG.CONTROLLER NEW IN BOX
OFFER & WIN- OMRON CS1W-IC102 I/O CONTROL UNIT
ZFV-SH50 Omron New In Box Vision Sensor ZFVSH50
Omron R88DUA20V AC Servo Drive with cables
(AB01) AC SERVO DRIVER OMRON R88D-HS04 WORKING
C200H-RT201 Omron PLC New In Box Remote I/O Rack Interface C200HRT201
C200H-RT201 Omron PLC New In Box Remote I/O Rack Interface C200HRT201
OMRON C500-GPC03 GRAPHIC PROGRAMMING CONSOLE
OMRON IDM P5+ INVERTER WITH VT5 CONTROLLER
(AJ01) CJ1G-CPU45H OMRON SYSMAC NEW
C200H-DA003 Omron PLC New In Box Analog Out C200HDA003
HPLC ALLIANCE ANALYTICAL AIR/LIQUID LAB MANIFOLD OMRON H3CA
CS1G-CPU44H Omron PLC New In Box CPU CS1GCPU44H
Matching Rack Cabinets w/Omron Sysmac C200HGCPU63 PLC System
Omron C200H Program Control Enclosure Complete Set-Up
Nice Omron AC Servo Drive Driver R88D-HT04 200/220VAC 65VA
C60K-CDS1-A New In Box Omron PLC CPU C60KCDS1A
C60K-CDT1-D New In Box Omron PLC CPU C60KCDT1D
(AB01) DRIVER-AC SERVO OMRON R88D-HS04 WORKING
(AB01) I/O UNIT OMRON FN515-MX212 WORKING
Omron Compplete PLC Sysmac C200H CPU C200H-CPU21-E
(AB01) DATA CONVERTER OMRON C500-AD101 D/A UNIT WORKING
(AB01) OMRON SYSMAC CQM1 PROGRAMMERBLE CONTROLLER PA203 CPU21 ID212 OD212 WORKIN
(AB01) POWER SUPPLY OMRON R88S-H205G WORKING
New Omron Power Supply, C500-PS213-E
Omron R88D-WT08H Servo Drive 200V 600-750W ! WOW !
C500-CP131 Omron PLC CAM Positioner Module C500CP131
CQM1-CPU44-E Omron PLC New In Box CPU CQM1CPU44E
OMRON C500-NC111-EV1 SERVO MODULE SINGLE AXIS STEPPER
(AA01) OMRON R88D-HT04 AC SERVO DRIVER WORKING
Omron E6F-AG5CC Rotary Encoder for H8PR-32 H8PR-16 H8PS-8PF Cam Positioners NEW
OMRON AC Vector Drive Model CIMR-G5U420P2 Pec#42P21F G5+ Series
(AJ01) OMRON PLC SYSMAC CJ1W-PA202 CJ1M-CPU13 NC113 X 2EA ID261 X 2EA TERMINAL
Omron Capacitive Proximity Switch E2K-C25ME2 Lot of 14 Brand New
OMRON CV500-RM211 REMOTE I/O UNIT GOOD TAKEOUT
OMRON V680-CA5D02 RFID SYSTEM ID CONTROLLER 24VDC NEW
OMRON CV500-SLK21 SYSMAC LINK UNIT For PLC REFURBISHED
OMRON CJ1W-V600C12 USPP CJ1WV600C12
OMRON F210-C10 & F160-KP without Camera&Monitor ,Vision Controller sn:22405
Omron Interactive Display NT631C-ST141-EV1
OMRON C200PC-ISA12-1 C200PC C200PC-CN221 Cable
Omron CJ1G-CPU44H CJ1GCPU44H NIB Free Ship
OMRON C200H-NC211/C200HNC211 Dual Axis Motion Module New!! OFFERS ACCEPTED!!
OMRON NT620S-ST211B HMI Touch Panel
Omron R88D-UA20HA AC Servo Driver NIB Free Ship
OMRON CPU Unit C200HX-CPU64-E New in Old Box Free Ship
OMRON CPU Unit C200HE-CPU33-E New in Box Free Ship
Omron NT600S-ST121B-V1 Diplay Panel Free Ship
Omron AC Servo Motor R88M-U1K030H-BS1 Free Ship
Omron IG000 3G8B3-IG000
OMRON C200PC-ISA13 C200PC with C200PC-CN221 Cable
Omron NT31C-ST142B-EV2 interactive display
Omron CJ1W-NC433 Free Ship
OMRON C250HL-CPU01-MK CPU UNIT/PLC ***XLNT***
Omron C200HX-CPU85-ZE C200HW-CLK21 C200H-CT021 PLC
Omron NT600S-ST121B-V3 Interactive Display Free Ship
OMRON HMI NT631C-ST151B-EV1 Touchscreen Free Ship
Omron NT631C-ST141-EV2 Free Ship
OMRON V530-LGCRXXX CORE 2D IMAGER HEAD NEW HARD TO FIND
OMRON NT620S-ST141 Free Ship
OMRON V680-CA5D01 V680CA5D01 ID CONT NEW
NEW KAWASAKI 9EH005282 ROBOT PC BOARD 10999EH02 OMRON XC2A 6412 8900 9EH-32 S4
Omron Interactive Display NTH25-ST121B Free Ship
OMRON ZX2-LD50L Free Ship
Omron NT631C-ST151-E Interactive Display Touchscreen
Omron CQM1-CPU43-V1 CQM1CPU43V1 CPU Controller
Omron E5ZE-8AQH04PB E5ZE8AQH04PB Temperature Controller 24VDC
OMRON Servo Motor R88M-W1K530H-BS2 Free Ship
OMRON C40H-C5DR-DE-V1 NSFP C40HC5DRDEV1
KEYENCE VISION CAMERA / CV-130 / CV-C11/ LED Light /Monitor /Remote Control
OMRON C200H-MAD01 ANALOG 2 IN/2 OUTPUTS
24032 NEW Omron 3F88L-132 Cam Positioner 100-240VAC 50/
LDQ-100A OMRON LED LIGHT *NEW*
Omron 3G2A5-OC221
Omron CV500-SLK11
Omron 3G2A5-OD213
Omron CVM1-BC053
Omron 3G2A9-BAT05
Omron 3G2C2-SI021
Omron E3N2-D2Y4B-US
Omron 3G2C5-BC001
Omron xy2z-100j-a1
Omron 3G2C5-DPL01-E
Omron 3G3MV-A2001
Omron c200h-bc000-v1
Omron C500-ID219
Omron C200H-BC101-V2
Omron 3G207-IP002
Omron E2CJ-R2-F
Omron 3G2A3-OD411
Omron C200HG-CPU43
Omron C200H-OD218
Omron 3G2A5-ID213
Omron CS1WBC102
Omron CV500-BC101
Omron 3G2A5-ID219
Omron 3G2A6-PRO15E
Omron CV500-II101
Omron 3G2A5-OA222
OMRON V530-H301 2D WAND V530H301 "NIB"
OMRON V530-R150E-3 "NIB" V530R150E3 CODE READER
Omron NSH5-SQR00B-V2 Handheld Interactive Display NEW E17
Omron NS5-MQ00B-V2 Interactive Display Touchscreen NEW A7
Omron,Minisafe,STI, MSF4800S-20-0600-10X-10R
OMRON F3SN-A0607P25-D Sensors *NIB* International Shipping Available
OMRON C500-NC103 NSPP C500NC103
OMRON V600-CA1A-N NSFP V600CA1AN
Omron STI MS430BB-2 MiniSafe Safety Light Curtain
MS4300B-2 Series Transmitter and Receiver MiniSafe-B
OMRON C200HW-SLK13 USPP C200HWSLK13
BRAND NEW OMRON PC CIRCUIT BOARD MODEL ORN-DSP-A2/2
Omron NT631C-ST141B-E Display Panel Free Ship
Omron NT631C-ST141B-V2 Display Panel Free Ship
OMRON CV500-MC421/CV500MC421 Servo Controller
Omron NT600G-DT212 NT600M-RT121 Free Ship
C200H-NC211 Omron PLC New In Box 2-Axis C200HNC211
V530-H301 Omron New In Box 2D Code Reader V530H301
OMRON SGMAH-08AAA61D-OY NSFP SGMAH08AAA61DOY
OMRON # C200H-TC003 CONVERTER MODULE, NIB
OMRON V600-CA1A-V2 NSPP V600CA1AV2
Omron C500-OD415CN, Used, C500OD415CN, Fast Shipping
Omron CJ1W-ETN21, Used, CJ1WETN21, Fast Shipping
OMRON C200HX-CPU44 USPP C200HXCPU44
Omron C200H-ASC11 C200HASC11 ASCII Unit
Omron PLC CS1G CPU44-V1 , CLK21 , DRM21 , ETN11 (E)
OMRON V620-CA1A USPP V620CA1A
OMRON CV500-BI111 NSPP CV500BI111
Omron NT31C-ST143B-EV3 NT31CST143BEV3 New in Box Free Ship
New OMRON touch screen NT31C-ST143B-EV3
OMRON C60K-CAR-A USPP C60KCARA
OMRON E4P-ALS400M1 NSFP E4PALS400M1
OMRON C40H-C6DR-DE NSFP C40HC6DRDE
Omron 3G3XV-A2004
Qty 6. Keyence LX2-V10W Digital Display Amps, Custom Setup, w/ 2 Omron Relays
1 new OMRON - C200H-NC211 - 2-AXIS STEPPER CONTROL-new
OMRON C200HW-NC113 NSFP C200HWNC113
OMRON C500-DA004 USPP C500DA004
OMRON C1000H-CPU01-EV1 USPP C1000HCPU01EV1
OMRON C1000H-CPU01-V1 USPP C1000HCPU01V1
OMRON C1000H-CPU01-E USPP C1000HCPU01E
OMRON C200HS-CPU01 USPP C200HSCPU01
Omron R7D-AP08H R7DAP08H Servo Drive
C200HGCPU63E NEW OMRON C200HG CPU63 E FREE SHIPPING
Omron C200HW-COM03-V1 C200HWCOM03V1
Omron NT631C-ST151B-EV1 Interactive Display HMI
OMRON C500-CT021 NSFP C500CT021
OMRON F10-S30R NSFP F10S30R
OMRON C200HG-CPU43-E
OMRON E3MC-MX11 USPP E3MCMX11
New Omron PLC CJ1M-CPU11-ETN
OMRON R88D-UP03H-AAC200V-50W USPP R88DUP03HAAC200V
OMRON H8PB-Y-30 USPP H8PBY30
OMRON H8PB-Y USPP H8PBY
OMRON NT20S-ST121B-EV3 USPP NT20SST121BEV3
OMRON R88D-UA03HA NSFP R88DUA03HA
OMRON E3MC-X11 USPP E3MCX11
OMRON F3W-A162-D USPP F3WA162D
在線咨詢 
